|
MATERIAL SAFETY DATA SHEET
Xinxiang Tiejun Pigments Co.,Ltd.
Guocun, Mengzhuang Town,
Huixian City, Henan, China |
Product: IRON OXIDE RED
MSDS No. IOR/01
Revision: Original
Date: June, 2002 |
HAZARD MATERIAL INDENTIFICATION SYSTEM
| Health Hazard |
0-Minimal |
| Falmmability Hazard |
0-Minimal |
| Reactivity Hazard |
0-Minimal |
| Personal Protection |
E-Glasses, Gloves, Dust Resp |
SECTION I. MATERIAL IDENTIFICATION
| Commodity/Material Name: |
IRON OXIDE RED |
| Description: |
Iron Oxide Red, C.I.Pigment Red 101. C.I.No.77491 |
| Chemical Name: |
Fe2O3 |
SECTION II. INGREDIENTS AND HAZARDS
| INGREDIENT NAME |
CAS NO. |
PERCENT |
EXPOSURE LIMITS |
| Iron oxide |
1309-37-1 |
 95 |
ACGIH TLV: 5mg/M3 TWA
(Iron Oxide Fume as Fe)
OSHA STEL:10PPM
(Iron Oxide Fume as Fe) |
| This product does not contain
toxic chemicals subject to the evidence found at present. |
SECTION III PHYSICAL/CHEMICAL
CHARACTERISTICS
| Boiling Point: N/A |
Solubility in Water: Insolube |
| Specific Gravity(H2O =1): 4.9 |
Vapor Pressure (mm/Hg): N/A |
| Appearance and Odor: Red to Reddish
Brown Powder, No Odor |
SECTION IV. FIRE AND EXPLOSION DATA
| Flash Point: |
Not flammable |
| Extinguishing Media: |
Foam, CO2, dry chemical
or water |
| Unsaual Fire or Explosion Hazards: |
None |
| Special Firefighting Procedures: |
Firefighters should use self-contained breathing
apparatus. |
SECTION V. REACTIVITY DATA
| Stability: |
Stable under ordinary conditions of use and
storage |
| Hazardous Polymerization: |
Will not occur |
| Conditions to Avoid: |
None known |
| Incompatibility (materials to avoid): |
Aluminum,, Ethylene Oxide, Ca(OCl)2,
N2H4 |
| Hazardous Decomposition or |
|
| Byproducts: |
None Known |
SECTION VI. HEALTH HAZARD DATA
| Summary of Health Risks and Symptoms
of Exposure: |
May cause mechanical skin and
eye irritation. Repeated and prolonged exposures to iron oxide
dust may cause a benign pneumoconiosis called siderosis. |
| Principal Routes of Entry: |
Inhalation,ingestion,skin and
eye irritation. |
| Accute Effects: |
Causes mechanical skin and eye
irritation. |
| Chronic Health Effects: |
Prolonged inhalation of iron
oxide dust is known to produce a condition known as siderosis.
On X-rays it appers to be a genign pneumoconiosis and is not
associated with pulmonary fibrosis or diasbility unless there
is concurrent exposure to other fibrosis-producing materials
such as silica.The TLV is set to protect against siderosis. |
| Emergency and First
Aid Procedures: |
| Eye Contact: |
Flush eyes with generous amounts
of water for at least 15-minute. Call a physician if irritation
persists. |
| Skin Contact: |
Wash skin with mild soap and
water. |
| Inhalation: |
Remove to fresh air.Call a physician. |
| Ingestion: |
If conscious, give large quantities
of water to induce vomiting. Get medical attention. |
SECTION VII PRECARTIONS FOR SAFE HANDLING,USE
OR DISPOSAL
| Spill/ Leak procedures: |
Vacuum or use wet clean-up techniques and
place waste material in closed container. |
| Waste management/disposal: |
Disposal must be made in accordance with national
or local regulations. Regulations currently in effect, discarded
iron oxide would not be classified as a hazardous waste. |
| Handling/Storing Precautions: |
Protect containers from damage and keep closed
when not in use. |
| Other Precautions: |
Observe good personal hygiene.Wash after handling. |
SECTION VIII SPECIAL PROTECTION INFORMATION
| Personal protective equipment: |
| Goggles: |
Wear safety glasses or goggles to protect
against dust particles. |
| Gloves: |
Leather or rubber gloves. |
| Respirator: |
Use of qualified dust respirator is recommended
when exposure limits may be exceeded. |
| Workplace Considerations: |
| Ventilation: |
Local exhaust ventilation to collector or
containment recommended to control dust to below exposure limits.Safety
Stations An eye wash station should be available to the area
of use. |
| Other: |
In accordance with good industrial hytiene
practice, avoid contact with skin,eyes or clothing, Avoid breathing
duct.Keep away from food products. Keep container closed when
not in use. Use with adequate, localized ventilation.Wash thoroughly
after handling and before eating,drinking. |
The information presented herein is believed to be accurate and
was obtained from sources believed to be reliable.However,the information
is provided without any representation or warranty,expressed or
implied,with respect to its accuracy or completeness.It is the users'
responsibility to determine the suitability of this product and
the relevance of this information for their use. Xinxiang Tiejun
Pigments Co.,Ltd. does not assume liability resulting from the use,handling,storage,and
disposal of this product.
|
